Maxon WL7 Especificações descarregar pdf (Página 10)

11921 Slauson Ave. Santa Fe Springs, CA. 90670 (800) 227-4116 FAX (888) 771-7713

PATENTS PENDING

NOTE: The Lift Controller counts the number of cycles & lifts over the lifetime of the

Lift. One CYCLE is counted each time the Lift is unfolded from the stowed posi-

tion to ﬂ oor level, lowered to the ground, raised to ﬂ oor level, and then stowed.

One LIFT is counted each time the Lift is lowered from ﬂ oor level to the ground,

and raised back to ﬂ oor level. Read the LIFTS and CYCLES counts from the Lift

Controller display window periodically so you know when to do the maintenance

checks listed below.

MAINTENANCE SCHEDULE

EVERY 500 LIFTS

NOTE: To conﬁ rm compliance with Federal Motor Vehicle Safety Standard 403, refer to

the COMPLETED LIFT INSTALLATION CHECKLIST in the Installation Manual.

Check that all Decals are in place, undamaged, and legible (see PARTS BREAK-

DOWN, DECALS).

Visually check the Lift for bent, broken, or worn out parts, and broken welds.

Check the electrical wiring for worn insulation, and the terminals for corrosion

and secure ﬁ t. Apply dielectric grease to connections if needed.

Replace both latch Solenoids P/N 266955-01 (see PARTS BREAKDOWN, ELECTRI-

CAL COMPONENTS, Item 23).

Check for loose fasteners (nuts, bolts, screws & rivets). Also, check cotter pins, clevis

pins, retaining ring pins & retaining rings for noticeable wear and damage.

Check that all anti-slip and safety striping is in place and undamaged (see PARTS

BREAKDOWN, ANTI-SLIP & SAFETY STRIPING).

EVERY 2500 CYCLES

Apply multi-use teﬂ on spray lubricant to all springs on the Lift.

EVERY 5000 LIFTS

Replace both Platform light bulbs P/N 906475-01 (see PARTS BREAKDOWN,

ELECTRICAL COMPONENTS, Item 8A).

Check both Hydraulic Cylinders for leaks. If a ﬁ lm of hydraulic ﬂ uid is visible on cyl-

inder seals Lift can still be operated. However, if ﬂ uid is dripping from the cylinders,

replace them (see PARTS BREAKDOWN, HYDRAULIC COMPONENTS, Item 13).

EVERY 10000 LIFTS

Clean dust and debris from Outboard Switch & Ground Switch (magnetic switches on

Platform). (See ELECTRICAL COMPONENTS in this Manual.)

1 2 ... 5 6 7 8 9 10 11 12 13 14 15 ... 86 87

Sem comentários

Maxon WL7 Especificações Página 10